Product ID:NUCLEAR GRADE DURALLOY BASE
MSDS Date:08/12/1988
FSC:8040
NIIN:00N035357
MSDS Number: BQGDG

PALMER INTERNATIONAL INC

WORCESTER, PA 19490
US

Emergency Phone: 215-584-4241

Info Phone: 215-584-4241

Cage: 00933

PALMER INTERNATIONAL, INC.

WORCESTER, PA 19490 US

Telephone: 610-584-4241

Cage: 00933

EPOXY PHENOL NOVOLAC RESIN; (EPOXY PHENOL NOVOLAC). LD50

CAS: 28064-14-4

Fraction By Weight: 2.5%

EPOXY RESIN

CAS: 25068-38-6

RTECS: KC2100000

Fraction By Weight: 22%

COLLOIDAL SILICA

CAS: 67762-90-7

Fraction By Weight: 2%

LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE IRRITATION. SKIN:
PROLONGED OR REPEATED CONTACT CAN CAUSE MODERATE IRRITATION,
DERMATITIS. INHAL: NORMALLY NO PROBLEM UNLESS HEATED. INGEST:
SLIGHTLY TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE:FLUSH W/LARGE AMTS OF WATER FOR @ LST 15 MIN LIFTING
EYELIDS OCCASNLY; GET PROMPT MED ATTN. SKIN:WASH THORO W/SOAP &
WATER, REMOVE CONTAM CLTHG PROMPTLY; WASH CLTHG BEFORE REUSE.
INGEST:DO NOT IND UCE VOMITING! KEEP PERSON WARM, QUIET &GET MED
ATTN. ASPIR OF MATL INTO THE LUNGS DUE TO VOMIT CAN CAUSE CHEM
PNEUMONITIS WHICH CAN BE FATAL. INHAL: MOVE AFFECTED PERSON TO
FRESH AIR. IF (SUPP DATA)

Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:SMALL/LARGE SPILL: SCRAPE UP/SOAK UP WITH
ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE.

Respiratory Protection:IF TLV IS EXCEEDED, NIOSH/MSHA APPRVD AIR SUPPLY
RESP IS ADVISED IN ABSENCE OF PROPER ENIVRON CTRL. OSHA REGS ALSO
PERMIT OTHER NIOSH/MSHA APPRVD RESPS UNDER SPECIFIED CNDTNS.
ENGINEERING/ADMIN CTRLS SHLD BE IMPLEMENTED TO REDUCE EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GEN AND/OR LOCAL EXHST) VENT
TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:NITRILE RUBBER.
Eye Protection:CHEMICAL WORKERS GOGGLES
Other Protective Equipment:EYE WASH; SAFETY SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: BREATHING HAS STOPPED, GIVE ARTIFICIAL RESPIRATION.
KEEP PERSON WARM, QUIET, AND GET MEDICAL ATTENTION.

HCC:N1
Boiling Pt:B.P. Text:>392F,>200C
Vapor Density:HVR/AIR
Spec Gravity:2.61
Evaporation Rate & Reference:NON VOLATILE
Appearance and Odor:GRAY PASTE
Percent Volatiles by Volume:0%

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS AND ACIDS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE AND DIOXIDE;
OXIDES OF NITROGEN.

Waste Disposal Methods:SMALL/LARGE SPILL: INCINERATE OR LANDFILL IN
ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.